Emergency line open 24/7 · Times shown in ET
Furnace installation and replacement
A cracked heat exchanger ends the repair conversation immediately. It is a carbon monoxide risk rather than a comfort fault, and no competent provider will patch one.
Your call connects you with an independent local HVAC provider. No obligation.
Call (855) 321-3194How much does furnace installation and replacement cost and how fast can I get it?
Furnace replacement runs a figure the provider confirms on site depending on equipment, venting and any fuel conversion. Call (855) 321-3194 and an independent local provider assesses the home and confirms their own price before any work begins.
Signs you need this service
- A cracked heat exchanger found on inspection
- Eighteen years or older with a major fault
- Repeated lockouts through the season
- Heat that no longer reaches the whole house
- Rising fuel costs against falling output
- A fuel conversion being considered
Signs replacement is the only safe option
Some furnace faults are repairable at any age. One is not. A cracked heat exchanger allows combustion products into the air stream, and the correct response is replacement regardless of how new the rest of the unit is.
Carbon monoxide and why this is urgent
Carbon monoxide has no colour and no smell, and the early symptoms of exposure resemble flu closely enough that people routinely miss them. A working alarm near sleeping areas is the only reliable warning, and it is among the least costly safety equipment in the house. If an alarm sounds, leave the building and call 911 from outside rather than investigating. Where a provider has condemned a furnace for a cracked exchanger, the unit should be shut off and tagged, not run gently until the replacement arrives.
Parts and failure points
| Part | What you notice |
|---|---|
| Furnace cabinet | Cracked heat exchanger or age |
| Flue and venting | Unsafe or non-compliant venting |
| Gas line connection | Resizing for a new appliance |
| Filter rack | Fitted to the new cabinet |
| Condensate kit | Required on high-efficiency units |
| Thermostat | Matched to the new control board |
What the visit looks like
- Site assessment
Existing venting, gas supply, electrical connection and filter rack all checked before equipment selection.
- Equipment sizing
Heat load calculation confirms the correct BTU output. Efficiency tier and fuel type agreed before the job proceeds.
- Installation and venting
Old unit removed, new furnace installed and vented. Gas connection tested for leaks before power is applied.
- Commissioning
Ignition sequence confirmed, flue gases measured and the provider walks you through the controls and filter location.
Repair or replace
Heating system decisions hinge on two risks that cooling systems don't share: a cracked heat exchanger and carbon-monoxide exposure. A confirmed crack is a replacement call regardless of system age, because patching a heat exchanger is not a code-accepted repair. Outside that scenario, age and the cost of the failed part guide the call the same way they do for cooling equipment.
Fuel costs also matter here. An older 80-AFUE furnace running against current gas rates may cost 20–25% more to operate than a 95-AFUE condensing unit. DOE Energy Saver heating and cooling covers efficiency ratings and seasonal operating cost comparisons if you want a baseline.
| Unit age | Minor fault | Major component or cracked exchanger |
|---|---|---|
| Under 10 years | Repair | Repair; verify heat exchanger integrity first |
| 10 to 16 years | Repair | Get a replacement quote; cracked exchanger = replace |
| 17 years or more | Repair as a bridge only | Replace: fuel savings offset replacement cost |
Safety panel
- Gas smell: leave the building, then call the gas utility or 911 from outside. Do not operate switches on your way out.
- Carbon monoxide alarm sounding: leave the building and call 911. Do not go back in to investigate.
- Electrical burning smell: shut off the breaker feeding the air handler and the condenser, then call.
- Refrigerant: handled only by technicians holding EPA Section 608 certification. Never vent or top up a system yourself.
Providers in this network work on equipment from Carrier, Trane, Lennox, Goodman, Rheem, York, American Standard, Bryant, Amana, Daikin, Mitsubishi Electric, Ruud. HVAC Emergency USA is an independent referral service and is not affiliated with, endorsed by or authorised by any equipment manufacturer.
The other angle
The same service written for cooling season: Furnace Installation and Replacement, cooling vertical.
Coverage
Find this service in your city
By state
Other heating services
- AC Repair
- AC Installation and Replacement
- Furnace Repair
- Heat Pump Repair
- HVAC Maintenance and Tune-Up
- Duct Cleaning and Sealing
- Thermostat Installation and Repair
- Boiler Repair
- Indoor Air Quality and Humidity
Related guides
Questions
Furnace Installation and Replacement questions
How much does furnace installation and replacement cost?
Typical completed jobs run a figure the provider confirms on site including parts and labor. A diagnostic visit is usually a figure the provider states up front. The provider confirms the exact figure on site before any work begins, and you approve it first.
How quickly can a provider attend?
The line is answered 24/7 in ET. Actual attendance depends on provider participation, your location, technician availability and demand that day. The operator tells you the window on offer rather than booking one nobody can meet.
Do you carry out the work yourselves?
No. HVAC Emergency USA is a referral service. We do not own trucks or employ technicians. We connect you with an independent local provider, and verifying their licence and insurance before work starts is your responsibility.
Do I have to be home for the visit?
Yes. The technician needs access to the thermostat and the equipment itself, and someone has to approve the quoted price before work begins. For combustion appliances they may also want to check alarms.
What should I do if I smell gas?
Leave the building first, then call the gas utility or 911 from outside. Do not operate light switches, thermostats or phones on your way out. Call us afterwards, once the property has been made safe.
What if the system is under warranty?
Parts warranties of five to ten years are common, labor warranties are not. Have the model and serial number ready so the provider can check coverage before fitting anything.
How do you choose the provider?
By ZIP code first, then by who is accepting calls. We publish no ratings and sell no placement. During a cold snap the set of available providers in a market narrows considerably.
Is there any charge for calling?
No. There is no charge to call and no obligation to proceed. We may be compensated by providers or partners when you call, which does not change what you are quoted or what you pay.
Written and fact-checked by the HVAC Emergency USA editorial team. Last updated . Editorial policy.